Recalls

Recalls & faults: Chrysler RS Voyager (2001-04)

Recalls: Chrysler RS Voyager

Overview

Manufacturers, or importers, issue recalls for defects or faults which have the potential to cause injury. Generally, manufacturers will inform the original buyers if their vehicle is subject to a recall and of the steps required to remedy the defect or fault. Please note that the recalls below (if any) are for Australian-delivered vehicles only. Furthermore, the number of recalls should not be taken as an indication of a model’s reliability or its safety more generally.

Recalls: Chrysler RS Voyager

Chrysler RS Voyager: brake pad friction blocks could separate

In May 2002, a recall was issued for Chrysler RS Voyager vehicles which may have been fitted with a particular type of front brake pad. For these vehicles, the brake pad friction blocks may separate from its backing plate, thereby compromising overall braking efficiency (PRA 2002/5403).

2002-04 model year Chrysler RS Voyager: power steering fluid leak

In November 2004, a recall was issued for model year 2002 to 2004 Chrysler RS Voyager vehicles due to the upper power steering return hose potentially splitting and leaking hydraulic fluid in the engine compartment, creating a fire hazard (PRA 2004/7388).


Problems and faults: Chrysler RS Voyager

Overview

This section identifies potential problems, causes and fixes based on the experiences of owners and repairers, online sources and technical service bulletins. This information is provided solely for reference purposes and AustralianCar.Reviews recommends that only properly qualified persons carry out repairs or modifications. Furthermore, the number of items below should not be taken as an indicator of a model’s reliability or the frequency with which they may occur.

To report a problem or fault to the AustralianCar.Reviews team, please use the Contact Us form. Note that AustralianCar.Reviews does not offer advice on automotive problems or disputes; such enquiries will not receive a reply. For vehicles purchased from dealers after 1 January 2011, please see our Australian Consumer Law fact sheet.

Chrysler RS Voyager: difficulty re-fuelling

In September 2009, Technical Service Bulletin (TSB) 14-001-09 REV A was issued for 2003-07 Chrysler RS Voyager vehicles with petrol engines. For these vehicles, the owner may experience difficulties when re-fuelling or the fuel pump nozzle may shut off repeatedly during re-fuelling. For these vehicles, the TSB described a diagnosis procedure which may identify the source of the problem as:

  • The fuel filler tube;
  • The vapour recirculation tube;
  • The fuel tank itself;
  • A blockage in the EVAP canister, ESIM, clean air hose or filter; or,
  • The control valve to the EVAP canister tube.

Chrysler RS Voyager: brake pipes may deform during steering rack replacement

In 2008, Chrysler UK issued a ‘non-code action’ for Chrysler Voyager vehicles because the brake pipes could deform during a steering rack replacement. For affected Chrysler Voyager vehicles, the brake pipes were to be inspected (NCA/2008/005).

Chrysler RS Voyager: Problems and faults

  • The engine may lose power or stall, especially at lower temperatures, requiring the throttle-position sensor to be replaced.
  • A tapping noise from the engine on start-up requires updated exhaust valve swivel pads.
  • The fuel gauge may give inconsistent readings but return to the correct level after about 10 minutes of driving due to a kinked hose at the leak detection pump filter.
  • Knocking or squawking noises from the front suspension may be corrected by replacing the sway-bar links.
  • The front passenger side carpet may be damp due to condensation from the air conditioning drain tube blowing back into the passenger compartment; replacing the tube with a longer one fixes the problem.
  • The air conditioning compressor may fail, causing a squealing or missing drive belt. Once the air conditioning parts are replaced, the body-control computer needs to be re-programmed.
  • For some early models, a serpentine belt may squeal or jumps off its pulley because of water leaking from the wiper-module drain tube – this was more common in extremely cold temperatures when ice could form on the pulley.
  • Where fitted, the power sliding sunroof may recognised a loose weather strip as an obstruction that causes it to malfunction when opening or closing; the weather strip should be replaced.


Back To Top