Recalls: Isuzu RC D-Max utility
Overview![Isuzu RC D-Max SX 4x2 Crew Cab utility: Splash White front quarter](data:image/svg+xml,%3Csvg%20xmlns='http://www.w3.org/2000/svg'%20viewBox='0%200%20300%20211'%3E%3C/svg%3E)
Manufacturers, or importers, issue recalls for defects or faults which have the potential to cause injury. Generally, manufacturers will inform the original buyers if their vehicle is subject to a recall and of the steps required to remedy the defect or fault. Please note that the recalls below (if any) are for Australian-delivered vehicles only. Furthermore, the number of recalls should not be taken as an indication of a model’s reliability or its safety more generally.
Recalls: Isuzu RC D-Max utility
2018 Isuzu D-Max Crew Cab: rear leaf spring could fracture
In April 2019, recall campaign S201910 was issued for Isuzu D-Max Crew Cab vehicles that were available for sale in Australia from 27 January 2018 to 16 October 2018. For vehicles that had three leaf rear suspension, the rear leaf spring could fracture due to the front eye being of insufficient diameter. If the rear leaf spring fractured, the parking brake cable may be unintentionally applied due to the rear axle being unsupported on the failed side – this could cause a collision. For the VINs of the recalled vehicles, please see PRA 2019/17434.
2018-20 Isuzu D-Max Crew Cab: rear leaf spring may fracture
In March 2020, recall campaign S202005 was issued for Isuzu D-Max Crew Cab vehicles that were available for sale from 27 January 2018 to 28 February 2020. In these vehicles, the rear leaf spring may fracture due to an insufficient diameter for the front eye. If one of the springs broke, the driver may not have full control of the vehicle – this increased the risk of a collision and injury to vehicle occupants and other road users. For the VINs of the recalled vehicles, please see PRA 2020/18230.
Problems and faults: Isuzu RC D-Max utility
Overview![Isuzu RC D-Max SX 4x2 HR Crew Cab utility: Mineral Grey front quarter](data:image/svg+xml,%3Csvg%20xmlns='http://www.w3.org/2000/svg'%20viewBox='0%200%20300%20179'%3E%3C/svg%3E)
This section identifies potential problems, causes and fixes based on the experiences of owners and repairers, online sources and technical service bulletins. This information is provided solely for reference purposes and AustralianCar.Reviews recommends that only properly qualified persons carry out repairs or modifications. Furthermore, the number of items below should not be taken as an indicator of a model’s reliability or the frequency with which they may occur.
To report a problem or fault to the AustralianCar.Reviews team, please use the Contact Us form. Note that AustralianCar.Reviews does not offer advice on automotive problems or disputes; such enquiries will not receive a reply. For vehicles purchased from dealers after 1 January 2011, please see our Australian Consumer Law fact sheet.
Isuzu RC D-Max: suspension squeak/noise
There have been reports of high-pitched, squeaking noises from the Isuzu RC D-Max’s suspension. While some dealers attempted to fix this by lubricating the bushes, the problem was that the angle of the shock absorber pin caused it to rub against and wear through the original bush. The pin would then contact the metalwork, causing the squeaking noise. Revised shock absorber pins and bushes were subsequently introduced and could be fitted to replace the original bushes.