Recalls: Skoda NH Rapid
Overview
Manufacturers, or importers, issue recalls for defects or faults which have the potential to cause injury. Generally, manufacturers will inform the original buyers if their vehicle is subject to a recall and of the steps required to remedy the defect or fault. Please note that the recalls below (if any) are for Australian-delivered vehicles only. Furthermore, the number of recalls should not be taken as an indication of a model’s reliability or its safety more generally.
Recalls: Skoda NH Rapid
2016 model year Skoda Rapid: faulty child lock
In July 2016, a recall was issued for certain Skoda NH Rapid vehicles because, due to damage during the production process, the detent lever of the child lock could break. An active child lock could therefore be unnoticeably switched off and enable the rear doors to be operable from inside the vehicle. As such, a child may be able to inadvertently open a rear door from the inside when the child lock appeared to be on – this could cause injury to a third party or increase the risk of injury to occupants inside the vehicle (PRA 2016/15518).
2017 model year Skoda Rapid: parts of seatbelt tensioner may dislodge
In July 2017, a recall was issued for ‘2017 model year’ Skoda Rapid vehicles because the gas generator of some front seatbelt tensioners may have been incorrectly crimped onto the actuator pipe of the belt tensioner. As a result, parts of the pyrotechnic system for the front seatbelts tensioners may become dislodged on deployment in the event of a collision and enter the vehicle’s interior, posing a hazard to vehicle occupants. For the VINs of the recalled Skoda Rapid vehicles, please see PRA 2017/16197.
2014-18 model year Skoda NH Rapid: Takata driver’s airbag recall
In July 2018, a recall was issued for 2014-18 model year Skoda Rapid vehicles. In these vehicles, the Takata-supplied driver’s airbag contained propellant wafers that could degrade over time due to the absorption of moisture. If the vehicle was in a collision that triggered the airbag, excessive internal pressure could cause the metal airbag inflator housing to explode/rupture, such that metal fragments would be projected through the airbag material and into the cabin – these metal fragments posed a serious risk of injury or fatality. For the VINs of the recalled vehicles, please see PRA 2018/16909.
2018 model year Skoda NH Rapid: driver airbag may not fully inflate
In July 2019, recall campaign 69Y9 was issued for 2018 model year Skoda NH Rapid vehicles. In some instances, the front driver airbag may not inflate to its fully capacity fast enough in the event of a collision and this increased the risk of injury to the driver. For the VINs of the recalled vehicles, please see PRA 2019/17652.
2014-15 model year Skoda NH Rapid DSG: pressure accumulator crack and loss of power
In October 2019, recall campaign 35E1 was issued for 2014-15 model year Skoda NH Rapid vehicles. Due to a production fault, a crack in the transmission’s pressure accumulator (within the mechatronics housing) could occur. If the pressure accumulator cracked, oil and pressure would be lost in the hydraulic system of the gearbox. If this occurred, the transmission of engine power would be interrupted, similar to depressing the clutch in a vehicle with a manual transmission – this increased the risk of a collision and injury to vehicle occupants. For the VINs of the recalled vehicles, please see PRA 2019/17887. AustralianCar.Reviews understands that the recalled vehicles had seven-speed DQ200 DSG transmissions.
Problems and faults: Skoda NH Rapid
Overview
This section identifies potential problems, causes and fixes based on the experiences of owners and repairers, online sources and technical service bulletins. This information is provided solely for reference purposes and AustralianCar.Reviews recommends that only properly qualified persons carry out repairs or modifications. Furthermore, the number of items below should not be taken as an indicator of a model’s reliability or the frequency with which they may occur.
To report a problem or fault to the AustralianCar.Reviews team, please use the Contact Us form. Note that AustralianCar.Reviews does not offer advice on automotive problems or disputes; such enquiries will not receive a reply. For vehicles purchased from dealers after 1 January 2011, please see our Australian Consumer Law fact sheet.
2012-13 Skoda NH Rapid with 7sp DQ200 DSG: electrolysis and short circuit
In 2014, Skoda UK issued a ‘non-code action’ for Skoda NH Rapid vehicles that had seven-speed DQ200 DSG transmissions and were manufactured from 1 October 2012 to 1 June 2013. For these Skoda Rapid vehicles, sulphur in the synthetic oil and an inorganic heat stabiliser in the plastic parts of the mechatronic unit could cause metallic surfaces to suffer from electrolytic corrosion, particularly in conditions with high temperatures and humidity. Conducting particles could then settle between the circuit paths of the control unit and cause a short circuit and blow the gearbox fuse. If the fuse were to blow, the clutch would open and freewheel, resulting in a sudden and total loss of power to the wheels. Although other vehicle systems such as steering and braking would continue to function, the loss of power may pose a hazard to occupants and other road users. For affected vehicles, the synthetic gearbox oil was to be replaced with mineral oil. Furthermore, the affected Skoda Rapid vehicles had VINs in the range TMBBT6NH0D4012035 to TMBBT6NHXD4028923 (NCA/2014/015).
In Australia, two separate recalls were issued for Skoda models with seven-speed DQ200 DSGs: one for vehicles manufactured between November 2008 and August 2011 (PRA 2013/13635) and one for ‘2013 model year’ vehicles (PRA 2014/14013). Since the Skoda NH Rapid was only released in Australia in 2014, however, it was not included in these recalls.
