Recalls: Toyota XW50 Prius
Overview
Manufacturers, or importers, issue recalls for defects or faults which have the potential to cause injury. Generally, manufacturers will inform the original buyers if their vehicle is subject to a recall and of the steps required to remedy the defect or fault. Please note that the recalls below (if any) are for Australian-delivered vehicles only. Furthermore, the number of recalls should not be taken as an indication of a model’s reliability or its safety more generally.
Recalls: Toyota XW50 Prius
2015-16 Toyota XW50 Prius: parking brake cable could disengage
In October 2016, a recall was issued for Toyota XW50 Prius vehicles that were manufactured from 18 August 2015 to 3 October 2016. In these vehicles, the parking brake cable could disengage from the rear brake calliper, causing the parking brake to become inoperative. If the parking brake did not engage and the transmission was left in a gear other than ‘park’, the vehicle could roll away and pose a safety hazard. The recalled Toyota Prius vehicles had VINs in the range JTD KB3FU # 03500110 to JTD KB3FU # 03538026 (PRA 2016/15676).
2015 Toyota XW50 Prius: airbags could be de-activated
In February 2018, a recall was issued for Toyota XW50 Prius vehicles that were manufactured from 27 November 2015 to 25 December 2015. Over time, insulation layers of the Integrated Circuit (IC) chip within the airbag system could peel and create an open circuit in the IC chip. If this occurred, the airbag warning light would illuminate and the side/curtain and/or front airbags could be de-activated – this increased the risk of occupant injury in the event of a collision. The Toyota XW50 Prius vehicles had VINs in the range JTD KB3FU # 03500164 to JTD KB3FU # 03503193 (PRA 2018/16585).
2015-18 Toyota XW50 Prius: engine wire harness could short circuit
In September 2018, recall campaign LGG58 was issued for Toyota XW50 Prius vehicles that were available for sale in Australia from 27 November 2015 to 14 May 2018. In these vehicles, a portion of the engine wire harness that was connected to the Power Control Unit could contact a connector cover and wear over time, causing an electrical short circuit. If sufficient heat were generated, there was an increased risk of fire. For the VINs of the recalled Toyota XW50 Prius vehicles, please see PRA 2018/17029.
2015-18 Toyota XW50 Prius: seatbelt reminder may not switch off
In February 2020, recall campaign VGG01 was issued for Toyota XW50 Prius vehicles that were manufactured from 27 November 2015 to 18 January 2018. Due to improper assembly of the electrical contact points in the reminder switch, there may be abnormal wear at the contact points may occur after repeated use of the seatbelt, causing residue to be deposited. Due to a short circuit between the contact points, the seatbelt reminder could not be turned off even when the seatbelt was correctly fastened – this would cause continual chiming and warnings on the instrument cluster that may distract the driver. To fix, the driver’s seatbelt buckle was to be replaced. For the VINs of the recalled vehicles, please see PRA 2020/18148.
Problems and faults: Toyota XW50 Prius
Overview
This section identifies potential problems, causes and fixes based on the experiences of owners and repairers, online sources and technical service bulletins. This information is provided solely for reference purposes and AustralianCar.Reviews recommends that only properly qualified persons carry out repairs or modifications. Furthermore, the number of items below should not be taken as an indicator of a model’s reliability or the frequency with which they may occur.
To report a problem or fault to the AustralianCar.Reviews team, please use the Contact Us form. Note that AustralianCar.Reviews does not offer advice on automotive problems or disputes; such enquiries will not receive a reply. For vehicles purchased from dealers after 1 January 2011, please see our Australian Consumer Law fact sheet.
Problems and faults: Toyota XW50 Prius
No troubleshooting information is currently available for the Toyota XW50 Prius.
