Recalls: Volkswagen Mk.6 Golf GTD
Overview
Manufacturers, or importers, issue recalls for defects or faults which have the potential to cause injury. Generally, manufacturers will inform the original buyers if their vehicle is subject to a recall and of the steps required to remedy the defect or fault. Please note that the recalls below (if any) are for Australian-delivered vehicles only. Furthermore, the number of recalls should not be taken as an indication of a model’s reliability or its safety more generally.
Recalls: Volkswagen Mk.6 Golf GTD
2009-11 Volkswagen Mk.6 Golf GTD: potential fuel leak
In February 2012, a recall was issued for Volkswagen Mk.6 Golf models fitted with 2.0-litre turbo-diesel engines and manufactured between 2009 and 2011. In these vehicles, the engine’s fuel injection pulses could coincide with the natural frequency of the injector line, producing a resonance that creates additional stress in the fuel line. As a result, the injector line for the number two cylinder could develop small cracks and cause fuel to leak. In the presence of an ignition source, a fire could therefore result. To fix, Volkswagen installed an improved fuel injector line for the number two cylinder and vibration dampers on all of the injector lines (PRA 2012/13017).
Volkswagen Mk.6 Golf GTD with DQ250 DSG: loss of power
In June 2013, a recall was issued for Volkswagen Mk.6 Golf vehicles that had six-speed DQ250 Direct Shift Gearboxes (DSGs); AustralianCar.Reviews understands that the recalled vehicles were manufactured from 1 September 2008 to 31 August 2009. In these vehicles, the wiring harness of a temperature sensor within the transmission may have insufficiently crimped connector wires. This could cause the temperature sensor to incorrectly detect high gearbox oil temperatures and activate the clutch protection function – this would illuminate a flashing gear warning light and cause 1) juddering of the vehicle, 2) a reduction in engine torque, and 3) opening of the clutch (as if the gearbox were in ‘neutral’). As such, loss of power to the wheels could pose a hazard to occupants of the vehicle and other road users. For the recalled vehicles, Volkswagen provided a software update for the gearbox control unit (PRA 2013/13625).
2010-12 Volkswagen Mk.6 Golf GTD: diesel engine NOx emissions
In October 2015, a recall was issued for 2010-12 Volkswagen Mk.6 Golf GTD vehicles with 2.0-litre EA189 diesel engines. According to the recall notice, ‘the emissions levels may not meet regulatory requirements when the affected vehicle is driven under normal conditions’ (see ‘Diesel engines: NOx emissions “defeat device”‘, below). For the 2.0-litre EA189 engine, a software update will be introduced which takes advantage of improved simulation of air currents inside the air intake system. Volkswagen aims to implement the software update from January 2016; the labour time for installing the updated software is around half an hour. Owners could determine if their vehicles were part of the recall by visiting volkswagendieselinfo.com.au (PRA 2015/14950).
2009 and 2010 model year Volkswagen Golf: ABS and ESC may not operate
In March 2017, a recall was issued for 2009 and 2010 model year Volkswagen Golf vehicles. In these vehicles, thermal overload within the ABS/ESC control unit could interrupt the current flow and this could prevent the ABS and ESC systems from functioning as intended; a warning light would also illuminate on the dashboard. In critical driving situations, the absence of ABS and ESC could increase the risk of a collision and injury to vehicle occupants. As part of the recall, the software for the ABS/ESC control unit would be updated to regularly check the operation of the unit (PRA 2017/15956).
2011-12 model year Volkswagen Mk.6 Golf GTD: overheating of starter motor relay
In March 2018, a recall was issued for 2011 and 2012 ‘model year’ Volkswagen Mk.6 Golf GTD vehicles. In these vehicles, a bent or broken spring could obstruct the clearance of the spindle in the starter motor relay. Over time, this could cause a blockage, a permanent current supply to the starter motor and overheating of the starter motor relay. If the current supply was not detected, overheating of the starter motor relay could cause local scorching damage and a possible vehicle fire. For the VINs of the recalled vehicles, please see PRA 2018/16669.
2010-12 Volkswagen Mk.6 Golf GTD: Takata airbag recall
In December 2018, recall campaign 69Q7 was issued for Volkswagen Mk.6 Golf GTD vehicles. These vehicles had Takata airbags and the propellant wafers in these airbags could absorb moisture over time. In the event of airbag deployment, excessive internal pressure could cause the metal inflator housing to rupture and metallic fragments could be projected through the airbag cushion towards vehicle occupants – these fragments posed a risk of serious injury and fatality. For the VINs of the recalled vehicles, please see PRA 2018/17197.
2010-12 Volkswagen Mk.6 Golf GTD: Takata airbag recall
In June 2019, recall campaign 69Q7 was issued for Volkswagen Mk.6 Golf GTD vehicles. These vehicles had Takata driver’s airbags and propellant wafers inside these airbags could absorb moisture over time. In the event of airbag deployment, excessive pressure in the airbag inflator housing could cause it to rupture and metal fragments could be projected through the airbag cushion and into the vehicle’s cabin. These metal fragments posed a risk of serious injury and fatality. For the VINs of the recalled vehicles, please see PRA 2019/17582.
Problems and faults: Volkswagen Mk.6 Golf GTD
Overview
This section identifies potential problems, causes and fixes based on the experiences of owners and repairers, online sources and technical service bulletins. This information is provided solely for reference purposes and AustralianCar.Reviews recommends that only properly qualified persons carry out repairs or modifications. Furthermore, the number of items below should not be taken as an indicator of a model’s reliability or the frequency with which they may occur.
To report a problem or fault to the AustralianCar.Reviews team, please use the Contact Us form. Note that AustralianCar.Reviews does not offer advice on automotive problems or disputes; such enquiries will not receive a reply. For vehicles purchased from dealers after 1 January 2011, please see our Australian Consumer Law fact sheet.
Diesel engines: NOx emissions “defeat device”
Australian-delivered Volkswagen Mk.6 Golf GTD vehicles powered by 2.0-litre diesel engines that were available for sale from 2010 to 2012 had software in the electronic control module (ECM) that could sense – via sensors measuring the position of the steering wheel, vehicle speed, the duration of the engine’s operation and barometric pressure – when the vehicle was undergoing emissions testing. The ECM would then run a ‘dyno calibration’ to produce lower nitrous oxide emissions during testing. At all other times, the ECM would run a separate ‘road calibration’ which reduced the effectiveness of the emission control system, specifically the selective catalytic reduction (SCR) or the lean NOx trap.
Based on testing conducted by the EPA and the California Air Resources Board (CARB), NOx emissions for the ‘road calibration’ were 10 to 40 times higher than US standards – this led the United States Environmental Protection Agency (EPA) to issue a notice of violation under the Clean Air Act.As a result, these vehicles did not meet the environmental standards claimed by Volkswagen.
Problems and faults: Volkswagen Mk.6 Golf GTD
- A lack of drainage may result in rainwater accumulating in the bottom of the doors.
- The alarm may be set off for no apparent reason – a software update is available for this problem.
